100GF5RT精研電機JSCC

100GF5RT

100GF5RT

100GF5RT

減速機選型步驟
減速機選型過程中需要知道的幾個系數：
　　1、工況系數
　　2、安全系數
　　3、環境溫度系數
　　4、負荷率系數
　　5、公稱功率利用系數
　　用戶需提高的參數包含：電機功率、電機轉速、所需要的功率、減速機所連接的工作機的轉速、每天工作時間、工作環境、溫度。
　　減速機選型步驟如下：
　　1、確定減速機的傳動比，按照公式：電機轉速/工作機轉速，根據用戶要求的傳動比選取接近的公稱傳動比。
　　2、確定減速機的公稱輸入功率
　　減速機的計算功率=減速機所連接的工作機械所需要功率*工作機械工況系數*安全系數
　　公稱輸入功率大于等于計算功率。
　　公式中出現的工作機械工況系數和安全系數是需查詢各個系列的減速機的樣本。算出計算功率后查詢對應的表知道公稱輸入功率，確定出減速機的名義中心距。
　　3、驗算起轉矩
　　公稱輸入功率大于等于（電動機的額定轉矩*輸入轉速*峰值轉矩系數）/9550
　　4、校核減速機的熱功率能否通過
　　熱功率=負載功率*環境溫度系數*負荷功率系數*公稱功率利用系數小于等于減速機功率（沒有冷卻措施的前提下）。對于圓柱齒輪減速機，只有采用盤狀管冷卻時，計算減速機功率（盤狀管冷卻或循環油潤滑）大于熱功率。因此可以選的減速機的型號，采用油池潤滑，盤狀水管通水冷卻潤滑油。如果不采用盤狀管冷卻，則需另選較大規格的減速機。
減速機選型需要注意以下問題：
盡量選用接近理想減速比：
減速比=伺服馬達轉速/減速機出力軸轉速
扭力計算：對減速機的壽命而言，扭力計算非常重要，并且要注意加速度的最大轉矩值(TP),是否超過減速機之最大負載扭力。
適用功率通常為市面上的伺服機種的適用功率，減速機的適用性很高，工作系數都能維持在1.2以上，但在選用上也可以以自己的需要來決定：
要點有二：
1、選用伺服電機的出力軸徑不能大于表格上最大使用軸徑；
2、若經扭力計算工作,轉速可以滿足平常運轉，但在伺服全額輸出時，有不足現象時，可以在電機側之驅動器，做限流控制，或在機械軸上做扭力保護，這是很必要的。
通用減速機的選型包括提出原始條件、選擇類型、確定規格等步驟。
相比之下，類型選擇比較簡單，而準確提供減速器的工況條件，掌握減速器的設計、制造和使用特點是通用減速機正確合理選擇規格的關鍵。
規格選擇要滿足強度、熱平衡、軸伸部位承受徑向載荷等條件。
減速機相關術語：
減速比：輸入轉速與輸出轉速之比；
級數：行星齒輪的套數。一般最大可以達到三級，效率會有所降低；
滿載效率：在最大負載情況下（故障停止輸出扭矩），減速機的傳遞效率；
工作壽命：減速機在額定負載下，額定輸入轉速時的累計工作時間；
額定扭矩：是額定壽命允許的長時間運轉的扭矩。當輸出轉速為100轉/分，減速機的壽命為平均壽命，超過此值時減速機的平均壽命會減少。當輸出扭矩超過兩倍時減速機故障；
噪音：單位分貝dB（A），此數值實在輸入轉速3000轉/分，不帶負載，距離減速機1米距離時測量值；
回差：將輸入端固定，是輸出端順時針和逆時針方向旋轉，當輸出端承受正負2%額定扭矩時，減速機輸出端由一個微小的角位移，此角位移即為回程間隙。單位是“分”，即一度的1/60。

sick CLX490-0010 OMNI Bar Code Scanner
From Canada

CLV490-3010 Sick New In Box Barcode Scanner 1019313 CLV4903010

Sick Optic PLS 101-312 PhotoElectric Safety Laser Scanner NIB PRCE REDUCED

SICK LUT1-450 LUMINESCENCT SCANNER 300MM RANGE LUT1450

SICK PLS201-313 PROXIMITY LASER SCANNER PLS201313 REPAIRED

SICK Laser Scanner S30A-7011BA - New in Box
From United Kingdom

Sick S30A-4011 safety laser scanner area zone NEW
From Canada

USED SICK PLS109-317 Proximity Laser Scanner

Sick CLX490-0010S05 Omni Barcode Scanner CLX490-0010S05
From China

SICK #LUT1450 SCANNER *RECONDITIONED*

SICK OPTIC CLV450-6010 BARCODE SCANNER ****NIB****

SICK Laser Scanner S30A-4011BA - Used
From United Kingdom

NIB Sick Barcode Scanner CLV490-3010 V5.00

SICK barcode scanner CLV490-0010

Sick Optic Scanner PLS101-112

USED SICK PLS101-312 Proximity Laser Scanner

CLV450 SICK Barcode Scanner

SICK PLS101-312 Proximity Laser Scanner PLS101312 Used

One-day shipping available
SICK S30A-4011BA SAFETY SCANNER

SICK AG PLS201-313 PROXIMITY LASER SCANNER SAFETY SYSTEM LIGHTGUARD

Sick CLV490-0010 CLV-490 Optic Bar Code Scanner LNC

Sick Area Scanner S30A-4011BA w/ replacement lens
From Canada

Sick Laser Scanner LMS210-30206 (60 Day Warranty)

SICK MODEL CLV260A1010 24VDC LASER SCANNER USED

SICK CLV410A1010 1 017 045 BARCODE SCANNER 1017045 NIB

SICK CLV490-0010 Optic Barcode Scanner

SICK PLS 101-112 PHOTOELECTRIC LASER SCANNER SENSOR

Sick Luminescence Scanner Sensor LUT1-530 1005933

SICK CLV490-3010 Optic Barcode Scanner

SICK PLS-101-312 LASER SCANNER PLS101312

NEW SICK OPTIC PLS100-111 LASER SCANNER PLS100111

Sick CLV431-6010 CLV4316010 Barcode Scanner
From Philippines

Sick Optics Luminescence Scanner LUT2-720 NEW IN BOX

No Test Spare Parts Only SICK S30A Safety Laser Scanner 7011CA W/O I/O Plug
From Hong Kong

Sick Luminescence Scanner LUT1-530 1005933 used
One-day shipping available

Sick Luminescence Scanner Sensor LUT1-530 1005933
One-day shipping available

New SICK Luminescense Scanner, LUT3-920, 1 019 286

SICK BARCODE SCANNER CLV265A1012

SICK BARCODE SCANNER CLV450-0010 NEW CLV4500010 1018556 V3.60 SOFTWARE

USED SICK CLV490-2010 Optic Barcode Scanner CLV 490

New SICK OTC-400 barcode scanner controller OTC-4001017866
One-day shipping available

SICK CONTRAST SCANNER SENSOR NT6-03022 WITH CABLE *FREE SHIPPING* NT 6

Sick LUT3-920 luminescence scanner NEW sensor
From Canada

SICK CLV420-0010 CLV 420 LASER BARCODE SCANNER, 1022031 - LINE SCAN / STANDARD /

SICK PLS101-112 PHOTOELECTRIC LASER SCANNER PLS101112

SICK LVU 706-2221 _ P/N #1003804 Scanner Light Curtain

One-day shipping available
SICK Bar Code Scanner CLV430-0010 1017709
One-day shipping available

Sick Scanner CLV 430-1010 NEW

NEW SICK OPTIC CLV220A1010 LASER SCANNER

SICK CLV220A1010 LASER SCANNER HEAD *NEW*

SICK PLS101-112 PHOTOELECTRIC LASER SCANNER PLS101112

SICK Barcode Scanner; Model CLV430-1010; Part 1016705

SICK OPTIC ELECTRONIC NT8-02412 NEW PHOTOELECTRIC SCANNER NT802412

Sick Luminescence Scanner p/n LUT1B-41225 **New In Box

USED SICK CLV295A0012 Optic Barcode Scanner CLV-295

Sick CLV490-0010 CLV-490 Optic Bar Code Scanner LNC Used

LD96910E PSC ( Sick Inc.) LazerData LD9000 Industrial Barcode Scanner �
One-day shipping available

SICK OPTIC PLS101-112 PHOTOELECTRIC LASER SCANNER ****XLNT****

SICK 1D BARCODE SCANNER, CLV422 Series, 10-30 volts
One-day shipping available

SICK CLV432 CLV432-6010 Fixfocus Advanced Barcode Scanner Bar Code Scanner
From China

SICK CLV440-0010 barcode scanner part number 1017588

NEW SICK CLV212A1010 BAR CODE SCANNER P/N 1 015 252

SICK (NT6-03025) SENSICK (NT 6) CONTRAST SCANNER // BRAND NEW //

CLV212A1010 Sick New In Box Barcode Scanner 1015252

SICK Lut1-400 Luminescense Scanner - Very Nice

Sick CS3-P1132 Optic Electronic Color Scanner

SICK CLV220A1010 LASER SCANNER HEAD *USED*

SICK Optic Scanner Luminescence LUT3-620

Sick Optics Photoelectric Luminescence Scanner LUT3-810

SICK Optic Scanner Luminescence LUT3-610

Sick CLV280A1020 Laser Scanner (60 Day Return Policy)

Sick optic electronic scanner CLV230-0010
From Singapore

Sick Optic Scanner LUT1 520 NEW ***

used sick scanner CLV450-6010

Sick Lut 1-5 Luminiscence Scanner
From Mexico

SICK 1 015 252 Barcode Scanner CLV212A1010 1015252 9925 5977 Used

One-day shipping available
SICK CLV620-0120 Barcode Scanner CDB620-001 Connection Module + Cables Full Kit!

SICK OPTEX NT8-02412 CONTRAST SCANNER

SICK CLV440-0010 CLV4400010 Barcode laser reader scanner

Sick Bar Code Scanner & Power Supply CLV410-1010

Sick CLV422-1910S02 Scanner Sensor

One-day shipping available
Newly listedSICK PLS-101-312 Proximity Laser Scanner w/ Power Supply Tested Works Great!

SICK OPTIC Contrast Scanner NT8-01 13010455
One-day shipping available

SICK Bar code scanners CLV431-0010

SICK CLV430-1010S03 CLV4301010S03 Barcode laser reader scanner

SICK BMV10-0111 CONNECTION MODULE FOR BAR CODE SCANNER
From United Kingdom

SICK CLV290-0010S03 Optic Barcode Scanner CLV 290 30 DAY WARRANTY
From Israel

PS56-1000 Sick New In Box Bar Code Scanner Power Supply 7025512 PS561000

Sick Scanner

SICK OPTIC ELECTRONIC NT802 USED PHOTOELECTRIC SCANNER NT802

SICK Barcode Scanner CLV410-1010
From Hong Kong

(#2917) Sick Contrast Scanner NT6-04025 Used

(#2918) Sick Contrast Scanner NT6-03025 Used

Newly listedSick NTL6-B11 Contrast Scanner w/Fiber-Optic cable NEW

New WOB Sick Contrast Control Scanner NT6 - 14920S17 1010615 DC 10 - 30 V

Sick Scanner 24v DC Power Supply - LCU-AM, NEW IN BOX!

SICK CLV212A1010 BAR CODE SCANNER 24VDC P/N 1 015 252

Sick NT8 NT8-01 Optic Electronic Contrast Scanner

Sick Barcode Scanner CLV410-1010 free ship
From Korea, South

Newly listedSick CLV430-0010 Scanner

Sick Optic Laser Bar Code Scanner CLV410A0010 1 017 044

One-day shipping available
OFFER & WIN SICK CLV410-1010 BARCODE SCANNER
From Poland

SICK OPTIC NT8-01 CONTRAST SCANNER D 7808

2PCS SICK CLV432 CLV432-6010 Fixfocus Advanced Barcode Scanner Bar Code Scanner
From China

Sick NT6 NT6-03012 Optic Electronic Contrast Scanner NEW

SICK CLV430-0010  Bar Code Scanner used/tested/working
From United Kingdom

SICK CLV414-0910S03 1 017 849 QUANTITY! 4.5-30VDC 3W AG BAR CODE SCANNER
From Canada

NEW!SICK FIBER OPTIC CABLE 2021299 AMV/BMV/SCANNER DB15

Sick CLV414-3010 scanner
From Singapore

SICK CLV210A1010 1 013 176 Bar Code Scanner